欢迎访问北京尚丰祥食品机械有限公司网站!

热线:13693237787 

大型洗菜机作业前应知道什么?

来源:https://www.sfxjxbj.com/ 浏览量: 时间:2022-03-15 13:04:24

大型洗菜机作业前须知:
Instructions before operation of large vegetable washing machine:
为了洗菜机作业及顺畅愉快,每次作业前之检查是很重要,务必逐项检视无误后,才可开始作业。
In order to ensure the safe, smooth and pleasant operation of the vegetable washing machine, the inspection before each operation is very important. The operation can be started only after the inspection item by item is correct.
1、开关箱之检查:切认无熔丝开关之电源线是否松脱,松脱必须确实旋紧;
1. Inspection of switch box: confirm whether the power line of non fuse switch is loose, and the loose must be tightened;
2、各部之链条、网状输送带、压送皮带、皮带之张力确认、调整。
2. Confirm and adjust the tension of chain, mesh conveyor belt, pressure conveyor belt and belt.
3、无段变速齿轮箱之齿轮机油,是否过量或不足,过量时请由放油塞处放出多余之机油,不足时请由加油口补充之。
3. Whether the gear oil of the endless transmission gearbox is excessive or insufficient. If it is excessive, please drain the excess oil from the oil drain plug. If it is insufficient, please supplement it from the oil filler.
洗菜机维护保养:
Maintenance of vegetable washing machine:
洗菜机维护保养务必先将电源开关关掉,使设备处于停机状态下记性。
For the maintenance of the vegetable washing machine, the power switch must be turned off first to keep the equipment in the shutdown state.
1、皮带调整:在二皮带轮之中间处,以手指(中指和食指)压皮带压缩量为7~12mm为标准值,大于标准值时,调整惰轮规定紧度。
1. Belt adjustment: at the middle of the two pulleys, take the finger (middle finger and index finger) pressing the belt compression of 7 ~ 12mm as the standard value. When it is greater than the standard value, adjust the idler pulley to the specified tightness.
2、链条调整:在两链轮的中间以手指(中指和食指)压链条,压缩量为4~ 9mm为标准值,超过标准值时,调整惰轮规定紧度。
2. Chain adjustment: press the chain with fingers (middle finger and index finger) in the middle of the two sprockets, and the compression amount is 4 ~ 9mm as the standard value. If it exceeds the standard value, adjust the idler gear to the specified tightness.
3、无段变速齿轮箱机油之点检加油及更换:严禁烟火得情况下拆掉检油塞,油刚流出为适当之量,不足时补充之。
3. Spot inspection, refueling and replacement of engine oil for stepless gearbox: it is strictly prohibited to remove the oil inspection plug under the condition of fireworks. The oil just flows out is the appropriate amount, and it shall be supplemented when it is insufficient.
蔬菜清洗机长期置放方法:
Long term placement method of vegetable washer:
如果洗菜机暂时不用需要搁置一端时间,这时的维护和保养更关重要,请务必按照以下方法操作。
If the vegetable washing machine is not used temporarily and needs to be put aside for one end of the time, the maintenance is more important. Please be sure to operate according to the following methods.
1、洗菜机各部件附着泥土、杂物等,用清水冲洗,用干布擦干,保持设备清洁;
1. All parts of the vegetable washing machine are attached with soil, sundries, etc., which shall be washed with clean water and wiped dry with a dry cloth to keep the equipment clean;
2、各回转部、皮带、链条等缠附之杂物、蔬菜叶,应完全。
2. All sundries and vegetable leaves wrapped around the rotating parts, belts and chains shall be completely removed.
3、各回转部及磨擦主动部,充分注油防止生锈。
3. All rotating parts and friction driving parts shall be fully oiled to prevent rust.
4、各链条充分注油,防止生锈。大型洗菜机
4. Each chain shall be fully oiled to prevent rust. Large vegetable washing machine

北京尚丰祥食品机械有限公司

备案号:京ICP备13030550号-2